电装编码规则new081107解析.docx

1、电装编码规则new081107解析七、电气设计代码手册（暂定）本标准适用于本公司船舶产品生产设计阶段的编码。规定了电装零件编码构成形式、含义及使用范围等。一） 电装代码总体构成说明：1、船号与船体定义的船号一致，详见船体结构编码；2、舾装代码常规舾装代码构成如下E P _ PD11S分段/总段/区域代码/单元代码（见注3）阶段代码（见注2）专业代码（见注1）备注：注1：专业代码：P 为管装，M 为机装，E 为电装，F 为甲装，V 为通风，A 为居装注2：阶段代码：C（内场）、B（分段）、U（单元）、P（总段平台）、Z（坞内）、D（码头）六个阶段；注3：分段/总段代码详见船体结构编码，区域代码详

2、见图1-1，单元代码为T+两位顺序号（数字0109）；3、编码3.1、电缆贯穿件编码 电缆贯穿件的编码规则如下： 贯穿件类型分如下几类： DA-电缆盒、DC-室内电缆筒、DX-控制台内电缆筒、DH-露天电缆筒、DK-电缆框3.2、电缆托架编码3.2.1、组装电缆直托架的编码如下： 托架类型：ZS重型组装单层电缆托架、ZD重型组装双层电缆托架、LS轻型组装电缆单层托架、LD轻型组装电缆双层托架托架长度规格：650，950，1250，1550，1850，2150，2450托架宽度规格：200，300，400，500，600，700，800例：LS2012032200宽，1250长，320的安装脚的

3、轻型电缆组装托架3.2.2、组装电缆单托架的编码如下：电缆托架类型：ZSD重型组装电缆单层单托架、ZDD、重型组装电缆双层单托架LSD轻型组装电缆单层单托架、LDD、轻型组装电缆双层单托架托架宽度规格：200，300，400，500，600，700，800例：LSD2050200宽，500的安装脚的轻型电缆组装单层单托架3.3、扁钢编码FA类型的为冷库专用的扁钢FB类型的扁钢厚度为4FC类型的扁钢厚度为6例：FB30551030宽， 550长，100脚高的普通扁钢FA30300530宽， 300长，100脚高的冷库扁钢3.4、填料函编码填料函型式：DTH焊接式填料函、DTG管式填料函填料函规格

4、：8、13、16、19、24、28、34、42、50、583.5、穿线管编码穿线管型式：DG鹅形弯管、DP直管穿线管填料函规格：8、13、16、19、24、28、34、42、50、583.6、设备支架编码设备型号或名称采用厂家标准或系统图里的设备名称，各条船不尽相同。例：HC101-FBPD11S-FDN_CCD9-5_1说明：华东船厂101号船（42000DWT散货船），由电装负责的在PD11S分段上安装的CCD9-5白炽舱顶灯型式1的支架。二） 设备中文英对照码SBDMSBM_CSBM_EA自动电话机Automatic telephone setA/D模数转换器A-D converterA

5、B报警铃Alarm bellAC集控室空调ECR air conditiomACJB房舱非水密分线盒Non-watertight branch box for accom.lightACP天线耦合器Antenna couplerADR空气干燥器Air dryerAEX自动电话交换机Exchanger for automatic telephoneAH汽笛Air hornAM放大器AmplifierANB卫通B天线Antenna for Inmarsat BANC卫通C天线Inmarsat C antennaAND中高频DSC天线MF/HF DSC antennaANR接收天线RX antenn

6、aANSS波段雷达天线S band radar scannerANSL锚灯Anchor lightANTX组合电台发射天线TX antenna for GMDSSAP广播主单元Amplifier unit for public addressAVR自动电压调节器Auto voltage regulatorBC蓄电池充电器Battery chargerBCC压载水控制台Ballast control consoleBCM土豆机Bean curd machineBCP充放电板Battery charging & discharging panelBL铃BellBR刹车Brake deviceBRS

7、W铜质开关Brass switchBT蓄电池BatteryBZ蜂鸣器BuzzerCB接线盒Connection boxCHTL海图桌灯Chart table lightCOMP补偿器CompensatorCONB控制箱Control boxCONP控制屏Control panelCOV转换阀Change over valveCP应发控制系统控制板Control panel for E/G control systemCR航向记录器Course recordCS旋转视窗Clear view screenCU通信单元Communication unitDAU遇险按钮Distress alert u

8、nitDCR两用记录器Dual channel recorderDI测深仪数显Digital displayDPS压差开关Different press switchDRM烘干机Dryer machineDS烟探Smoke detectorDSU调速器控制单元Digital servo unitDT热探Heater detectorDTEX防爆温探Heater detector(ex-proof)DV泄放阀Drain valveE/G应急发电机Emcy generatorE/T应急变压器Emcy transformer (440/220)EAP延伸报警板Extension alarm pane

9、lEAW电焊机Electrican arc welderECC机舱集控台Engine control consoleELCR电灶Ele. cooking rangeELDB应急照明分配电箱Power distribution board for emcy lightELDB应急照明配电箱Emcy light distribution boardES测深仪记录器Echo sounder recorderESB应届配电板Emcy switch boardETSP电工试验板Electric test panelEU电子装置Electronic unitEXCL防爆顶灯Explosionproof c

10、eiling lightEXL防爆灯Ex. Poof lightF火焰探头Flame detectorFAP火警控制板Fire alarm control panelFAX气象传真机Facsimile receiverFBU反馈器Feed back unitFCOL荧光走道灯Fludrescent corridor lightFDEL荧光桌灯Fludrescent desk lightFLBL荧光床灯Fludrescent bed lightFLCL荧光顶灯Fludrescent ceiling lightFLWL荧光壁灯Fludrescent wall lightFMIL荧光镜灯Fludre

11、scent mirror lightFMNL前桅灯Fore mast lightFPM反馈装置Feedback pot meterFS浮子开关Float switchFT主机燃油流量传感器F.O. Flow sensorFTSW暗式双联开关Flush switch with two wayFV主机燃油流量计数器M/E F.O. Flow counterGAU调速器执行机构Governor actuator unitGCGMDSS组合台GMDSS consoleGLP组合报警板Group alarm panelGOV速度调节器Speed governorGP组合启动器Group starterG

12、PSDGPSDGPS navigatorGSP组合启动器屏Group starter panelHAI倾斜角指示器Heeling angle indicatorHCC倾斜控制箱Heeling control cabinetHLS静力液位传感器Hydrdstatic level sensorHPU液压动力单元Hyd. Pump unitHU湿度计HumidistatHVSL大船灯Huge vessel lightIDEL白炽桌灯Incandesent desk lightIDOL白炽下照灯Incandesent down lightIFOL白炽折叠灯Incandescent flod light

13、INCL白炽顶灯Iincandescent ceiling lightINFL白炽投光灯Incandescent flood light projectorINRL仪表灯Instrument lightINWL白炽壁灯Iincandescent wall lightIP仪表板Instrument panelIST本安电话机IS telephoneJB接线箱Junction boxJM主机接线箱M/E junction boxLC装载计算机Loading computerLCP升降机控制屏Lift control panelLIV液位阀Liquid valveLS限位开关Limit switch

14、LT液位传感器Level transmitterM马达MotorM/G主发电机Main generatorM/T主变压器Main transformer (440/220)MB测深仪匹配盒Matching boxMC磁罗径Magnetic compassMCC主控制箱Main control cabintMCK主钟Master clockMCU主控制箱Main control unitMD计程仪主显Master displayMEFL水银投光灯Mercury floood light projectorMEV主机燃油粘度控制板M/E F.O. Visc control panelMP主板Mai

15、n panel for bow thrusterMS报警笛Motor sirenMSB主配电板Main switch boardMSC马达起动箱Motor starter cabinetMSM锯肉机Meat saw machineMSSL莫氏信号灯Morse signal lightMU计程仪主单元Master unit for logMV主阀Main valveNCSL失控灯Not under command lightNQ麦克风插座MIC receiptacleNRV电话止回阀Non return valveOM主机油雾探测M/E oil mist detectorPB按钮盒Push bu

16、ttonPG主机测速传感器Pick-upPH电笛Piston hornPOHL手提灯Portable hand lightPRC卫通C打印机Printer for Inmarsat CPRM中高频打印机Printer for MF/HFPROB防护箱Protection boxPS压力开关Pressure switchPSNL左舷灯Port side lightPT压力传感器Pressure transmitterPU电源Power unitR终端电阻Terminal resistorRA舵角接收器Receiver for rudder angleRB继电器盒Relay boxRCU遥控单元R

17、emote control unitREFR冰箱RefrigatorRO无线电插座Radio outletRPM主机转速表M/E revolution indicatorRSB无线电开关箱AC/DC radio switch boxRT舵角发送器Transmitter for rudder angleS/G轴带发电机Shaft generatorSA话音放大器Speech amplifier unitSAL盐度计SalinometerSBNL右舷灯Starboard side lightSC岸电联接箱Shore connection boxSCK子钟Slave clockSESL操舵灯Stee

18、ring lightSOB汤锅Soup boilerSOCK插座SocketSOFL钠投光灯Sodium flood light projectorSP辅助板Slave plantSPK广播喇叭SpeakerSPT分配器SpilitSTNL艉灯Stern lightSTSW明式双联开关Surface switch with two waySTV蒸汽阀Steam valveSUB监测报警系统分站SubstationSUSW明式开关Surface switchSV电磁阀Solenoid valveSVB电磁阀箱Solenoid valve boardSW开关SwitchSWB开关箱Switch b

19、oxT变压器TransformerT/D测深仪传感器开关T/D changerTBM广播对讲Talkback master unitTC温控器Temp. controlTH冷却温度计Cooling thermoTLT温度和液位传感器Temp. and level transmitterTM转距马达Torque motorTR温度传感器Temp transmitterTRES测深仪传感器Transducer for echo sounderTRSL计程仪传感器Transducer for speed logTS温度开关Temp switchTSC收发机TransceiverUCM多用途炊具Unv

20、ersal cook machineUV紫外线传感器Ultraviolet radiation sensorVCB阀门控制箱Valve control boxVDU显示单元Video display unitVHF后桅灯Aft. Mast lightWAD垃圾处理机Waste disposerWAM自动洗衣机Auto washing machineWD风向仪Window direction indicatorWHCC驾驶室控制台Wheel house control consoleWS风速仪Window speed indicatorWTJB水密接线盒Watertight branch box

21、WW刮水器Window wiper三） 舱室中文对照码ROOMCODEROOM_CROOM_EACR空调机室AIR COND UNIT RMBCR压载控制室BALLAST CONTROL ROOMBO水手长室BOSUN RMBOL水手长卫生间BOSUN RM BOY LAVBR蓄电池室BATTERY ROOMBS海关储藏室BONDED STORECAPB船长卧室CAP BED RMCAPD船长办公室CAP DAY RMCAPL船长卫生间CAP LAVCAPM船长会议室CAP MEETING RMCC大厨室CHIEF COOKER ROOMCD充放电室CHARG AND DISCHARG ROO

22、MCEBR轮机长卧室C/E BED RMCEDR轮机长办公室C/E DAY RMCEL轮机长卫生间C/E LAVCGL清洁用具间CLEANING GEAR LOCKERCH乙炔间CL船员洗衣室CREWS LAUNDRYCLA厨工室卫生间COOK RM LAV。CMR船员餐厅CREWS MESS RMCO厨工室COOK RMCOB大副卧室C/OFF BED RMCOD大副办公室C/OFF DAY RMCOL大副卫生间C/OFF LAV.COR二氧化碳室CO2 ROOMCP船员配餐间CREWS PANTRYCPR木工室CARPENTERCR会议室COMMUNITY RMCRR船员娱乐室CS海图区域

23、CHART SPACECSR船员吸烟室CREWS SMOKING RMCT电缆槽C.T.CTP电缆槽(左)C。T。P.CTS电缆槽(右)C。T。S。DC甲板部见习生室DECK CADETDCH甲板部更衣室DECK CHANGING RM.DCL甲板部见习生卫生间DECK CADET BOY LAVDMR值班餐厅DUTY MESS RMDO甲板部办公室SHIP OFFICE BALLAST DPL干货储藏室DRY PROVISION LOCKERDPS干粮储藏室DRY PROVISION STOREDR乳品库DAIRY ROOMDRM烘衣室DRYING RMDS日用品储藏室DAILY PROVI

24、SION STOREEBR电机员卧室ELECTRICAN BED ROOMEC轮机部见习生室ENGINE CADET RM。ECA机舱棚ENGINEECH轮机部更衣室ENGINE CHANGING ROOMECL轮机部见习生室卫生间ENGINE CADET LAVECR机舱集控室EDR电机员办公室ELECTRICAN DAY ROOMEE机舱入口EGR应急发电机室EMERGENCY GENERATER ROOMEL电工室ELECTRICIAN ROOMELL电工室卫生间ELECTRICIAN LAV。ELS电机员室ELECTRICAN ROOMEM电梯机房ELE。M。RM。EO轮机部办公室EN

25、GINE OFFICEER诊疗室EXAMINATION ROOMES电器设备室ELECTRIC EQUIPMENT STOREET逃口EWR电工间FAI新鲜空气进气口FRESH AIR INTAKEFBL装配工室卫生间FITTER BOY LAVFCR消防控制室FIRE CONTROL ROOMFEB大管卧室/ENG BED RMFED大管办公室/ENG DAY RMFEL大管卫生间/ENG LAV.FI装配工室FITTERFIL第五储藏室NO5 LOCKERFL第一储藏室NO1 LOCKERFO加油长室FOI加油员室FR鱼库FISH ROOMFUL第四储藏室NO4 LOCKERGA厨房GAL

26、LEYGM健身房GYMNASIUMGS垃圾储藏室GARBAGE STOREGY活动室GYMNSIUMHO电梯间ELE。M。RM。HOL病房卫生间HOSPITAL BOY LAVHOS病房HOSPITALHS处理区IS隔离室ISOLATIONLB门厅LOBBYLL被服库LINEN LOCKERLRM洗衣室MB服务员室MESS BOY RMML药品储藏室MED。LOCKERMR肉库MEAT ROOMMSBR机舱主配电间NIR航海仪器储藏室NAVIGATE INSTRUCTION ROOMNO机工长室NO。1 OILERO氧气间OBR船东卧室ODR船东办公室ODRM干部烘衣室OFS干部储藏室OFFS STOREOI机匠室OILER RMOIL机匠室卫生间OILER RM BOYS LAVOL干部洗衣室OFF。LAUNDRYOMR干部餐厅OFFS MESS RMOP干部配餐间OFF